Engine-Codes - Ford - P0455 2009 Ford Fusion

P0455 2009 Ford Fusion Code - Evaporative Emission Control System Leak Detected Gross Leak

- Code Popularity: 6,831 Views
- Repair Importance Level: 1/3
- Repair Difficulty Level: 3/3
Table of contents
ChatAC AutoCodes.com AI Chat

What are the Possible Causes of the DTC P0455 2009 Ford Fusion?

NOTE: The causes shown may not be a complete list of all potential problems, and it is possible that there may be other causes.
  • Missing or loose fuel cap
  • Incorrect fuel filler cap used
  • Fuel filler cap remains open or fails to close
  • Foreign matter caught in fuel filler cap
  • EVAP canister or fuel tank leaks
  • EVAP system hose leaking
  • Fuel tank leaking

Code Tech Notes

The P0455 it’s a very common code, because the code is set if the gas cap is loose or missing. Start by tighten the gas cap and clearing the code. In most cases the code can be clear by disconnecting the car battery for about 30 minutes.

⚠ Does your Ford have Safety Recalls? → Check here

How to Fix the DTC P0455 2009 Ford Fusion?

Check the 'Possible Causes' listed above. Visually inspect the related wiring harness and connectors. Check for damaged components and look for broken, bent, pushed out, or corroded connector pins.

Search for P0455 2009 Ford Fusion Questions and Answers: Search here →

What is the Cost to Diagnose the Code?

Labor: 1.0

The cost to diagnose the P0455 2009 Ford Fusion code is 1.0 hour of labor. The diagnosis time and labor rates at auto repair shops vary depending on the location, make and model of the vehicle, and even the engine type. Most auto repair shops charge between $75 and $150 per hour.

When is the Code Detected?

EVAP control system has a very large leak such as fuel filler cap fell off, EVAP control system does not operate properly.

What are Code Possible Symptoms?

  • Engine Light ON (or Service Engine Soon Warning Light)
  • A noticeable fuel odor may result from fuel vapor release

What Does the P0455 2009 Ford Fusion Code Mean?

The Powertrain Control Module (PCM) monitors the complete evaporative emission (EVAP) control system for no purge flow, the presence of a large fuel vapor leak, or multiple small fuel vapor leaks. System failure occurs when no purge flow, which is attributed to fuel vapor blockages or restrictions, a large fuel vapor leak, or multiple fuel vapor leaks are detected by the EVAP running loss monitor test with the engine running, but not at idle.

P0455 2009 Ford Fusion Code - Evaporative Emission Control System Leak Detected Gross Leak

Need more Information on the Code?

Need more information on how to fix the P0455 2009 Ford Fusion code? Get Access to Factory Service Manuals

Need Help with the Code?

Get the P0455 2009 Ford Fusion code diagnosed by a professional: Find a repair shop in your area