Engine-Codes - Ford - P1120 2001 Ford F150

P1120 2001 Ford F150 Code - Throttle Position Sensor Out of Range

- Code Popularity: 6,879 Views
- Repair Importance Level: 3/3
- Repair Difficulty Level: 2/3
Table of contents
ChatAC AutoCodes.com AI Chat

What are the Possible Causes of the DTC P1120 2001 Ford F150?

NOTE: The causes shown may not be a complete list of all potential problems, and it is possible that there may be other causes.
  • Faulty throttle position sensor
  • Throttle position sensor harness is open or shorted
  • Throttle position sensor circuit poor electrical connection
  • Throttle position sensor not properly adjusted

Code Tech Notes

The TP sensor circuit is monitored by the PCM for a low TP rotation angle (or voltage) input below the closed throttle position through the comprehensive component monitor (CCM). If during key ON engine OFF or key ON engine running the TP rotation angle (or voltage) remains within the calibrated self-test range but falls between 3.42 and 9.85% (0.17 and 0.49 volt), the test fails.

⚠ Does your Ford have Safety Recalls? → Check here

How to Fix the DTC P1120 2001 Ford F150?

Check the 'Possible Causes' listed above. Visually inspect the related wiring harness and connectors. Check for damaged components and look for broken, bent, pushed out, or corroded connector pins.

Search for P1120 2001 Ford F150 Questions and Answers: Search here →

What is the Cost to Diagnose the Code?

Labor: 1.0

The cost to diagnose the P1120 2001 Ford F150 code is 1.0 hour of labor. The diagnosis time and labor rates at auto repair shops vary depending on the location, make and model of the vehicle, and even the engine type. Most auto repair shops charge between $75 and $150 per hour.

When is the Code Detected?

Malfunction is detected when voltage from the sensor is sent to Engine Control Module (ECM) is out of range.

What are Code Possible Symptoms?

  • Engine Light ON (or Service Engine Soon Warning Light)
  • No throttle response

What Does the P1120 2001 Ford F150 Code Mean?

The Throttle Position Sensor (TPS) responds to the accelerator pedal movement. The TPS is a rotary potentiometer sensor that provides a signal to the Powertrain Control Module (PCM) that is linearly proportional to the throttle plate/shaft position. As the TPS is rotated by the throttle shaft, the following operating conditions are determined by the PCM:
• Closed throttle (includes idle or deceleration)
• Part throttle (includes cruise or moderate acceleration)
• Wide open throttle (includes maximum acceleration or de-choke on crank)
• Throttle angle rate

P1120 2001 Ford F150 Code - Throttle Position Sensor Out of Range

Need more Information on the Code?

Need more information on how to fix the P1120 2001 Ford F150 code? Get Access to Factory Service Manuals

Need Help with the Code?

Get the P1120 2001 Ford F150 code diagnosed by a professional: Find a repair shop in your area